Published since 1923
DOI: 10.33622/0869-7019
Russian Science Citation Index (RSCI) на платформе Web of Science


  • BUILDING MATERIALS AND PRODUCTS
  • Influence Of The Specific Surface Area Of Hydro-Removal Ash On The Properties Of Ash-Cement Stone
  • UDC 691.33
    doi: 10.33622/0869-7019.2023.02.73-80
    Alexander V. YAVINSKIY, 121qqz@mail.ru
    Irina L. CHULKOVA, le5@inbox.ru
    Siberian State Automobile and Highway University (SibADI), prospekt Mira, 5, Omsk 644080, Russian Federation
    Abstract. The problem of storage of hydraulic removal ash in ash dumps is considered. The negative impact on the ecology caused by the accumulation of such ash in the ash dump has been noted. Overview data on the processing of hydraulic removal ash in Russia and abroad are given. It is established that the largest amount of ash in the world is disposed of in the construction industry. Changes in humidity and specific surface area of hydraulic removal ash of the Omsk region depending on the depth of occurrence in the dump were studied, its chemical composition was determined and it was revealed that this ash belongs to the ultra-acidic. The effect of ultra-acid hydro-removal ash on the strength and water absorption of ash-cement stone was studied at its different specific surface and the amount of ash introduced. It is proved that the strength of the ash-cement stone increases with an increase in the specific surface of the hydraulic removal ash. A rational amount of introduction of hydro-removal ash was determined to obtain a mixed binder with a specific surface area established empirically. With this replacement, there is a slight decrease in strength and an increase in water absorption compared to the control ashless sample.
    Keywords: hydro-removal ash, specific surface area of ash, ash-cement binder, cement stone, road construction, ecology
  • REFERENCES
    1. Bazhenov Y. M., Alimov L. A., Voronin V. V. Struktura i svoystva betonov s nanomodifikatorami na osnove tekhnogennykh otkhodov: monografiya [Structure and properties of concretes with nanomodificators on the basis of man-made waste: monograph]. Moscow, MGSU Publ., 2013. 204 p. (In Russ.).
    2. Lunev A. A. Mechanical strength of ash-and-slag crushed stone of coal-fired thermal power plants. Vestnik MGSU, 2020, vol. 15, no. 7, pp. 968-979. (In Russ.). doi: 10.22227/1997-0935.2020.7.968-979
    3. Haleem A., Luthra S., Mannan B. et al. Critical factors for the successful usage of fly ash in roads & bridges and embankments: Analyzing Indian perspective. Resources Policy, 2016, vol. 49, pp. 334-348. doi: 10.1016/j.resourpol.2016.07.002
    4. He Y., Luo Q., Hu H. Situation analysis and countermeasures of China's fly ash pollution prevention and control. Procedia Environmental Sciences, 2012, vol. 16, pp. 690-696. doi: 10.1016/j.proenv.2012.10.095
    5. Fedorova N. V., Mohov V. A., Babushkin A. Yu. Analysis of foreign experience in the use of ash and slag waste from TPPs and the possibilities of multi-agent modeling of recycling processes (Review)]. Ekologiya promyshlennogo proizvodstva, 2015, no. 3(91), pp. 2-7. (In Russ.).
    6. Shin J., Natanson A., Khun J. et. al. Assessing the impact of coal ash exposure on soil microbes in the Dan river. BIOS, 2017, vol. 88, iss. 2, pp. 72-85. doi: 10.1893/BIOS-D-16-00006.1
    7. Lunyov A. A. Substantiation of the calculated values of mechanical characteristics of pond ash and slag mixtures for the design of the roadbed. Available at: https://sibadi.org/upload/disser/lunev/lunev_.pdf?ysclid=ldiu0blzmx653369427 (accessed 17.08.2022). (In Russ.).
    8. Transport strategy of the Russian Federation for the period up to 2030. Available at: https://mintrans.gov.ru/documents/3/1009 (accessed 17.08.2022). (In Russ.).
    9. Suvorov D. N., Hakimov Z. L., Chantieva M. E. Automation of operational control of granulometry and bitumen fraction in the production of asphalt concrete mixture. Vestnik MADI, 2009, no. 3(18), pp. 106-109. (In Russ.).
    10. Kramar L. Ya. Cement heavy concretes for construction of high-speed roads. Vestnik TGASU, 2017, no. 4(63), pp. 147-157. (In Russ).
    11. Racional'noe primenenie zoly TEC: Rezul'taty nauchno-prakticheskih issledovaniy [Rational application of ash from TPPs: The results of scientific and practical research]. Compiled by Guzhulev E. P., Usmanskiy Yu. T. Omsk, OmGTU Publ., 1998. 238 p.
    12. Bryukhan' F. F. The use of ash and slag waste from coal-fired thermal power plants for the production of building materials. Aktual'nye problemy stroitel'noy otrasli i obrazovaniya. Sbornik dokladov I Nacional'noy konf. [Actual problems of the construction industry and education. Collection of reports of the I National Conference (Moscow, September 30, 2020)]. Moscow, MGSU Publ., 2020, pp. 225-228. (In Russ.).
    13. Vatin N. I., Petrosov D. V., Kalachev A. I. et al. Application of ashes and ash-and-slag wastes in construction. Inzhenerno-stroitel'ny zhurnal, 2011, no. 4(22), pp. 16-21. (In Russ.).
    14. Afanas'eva O. V., Mingaleeva G. R., Dobronravov A. D., Shamsutdinov E. V. Integrated use of ash and slag waste. Izvestiya vuzov. Problemy energetiki, 2015, no. 7-8, pp. 26-36. (In Russ.).
    15. Hozin V. G. Efficiency of application of fly ash of Gusinoozerskaya TPP in the composition of cements of low water consumption. Stroitel'nye materialy, 2011, no. 7, pp. 76-78. (In Russ.).
    16. Yavinskiy A. V., Chulkova I. L. Study of physical and mechanical properties of heavy concrete with ash from hydro dump. Obrazovanie. Transport. Innovacii. Stroitel'stvo. Sb. materialov IV Nacional'noy nauchn.-prakt. konf. [Proc. of the IV National scientific-practical conference (Omsk, April 22-23, 2021)]. Omsk, SibADI Publ., 2021, pp. 671-675. (In Russ.).
    17. Bhangale P. P., Nemade P. M. Study of pond ASH (BTPS) use as a fine aggregate in cement concrete-case study. International Journal of Engineering Trends and Technology, 2013, vol. 2, pp. 292-297.
    18. Arumugam K., Ilangovan R., Manohar D. J. A study on characterization and use of pond ash as fine aggregate in concrete. International Journal of Civil & Structural Engineering, 2011, vol. 2, no. 2, pp. 466-474.
    19. Ganesh B. Characterisation of pond ash as fine aggregate in concrete. Proc. of International conference on advances in architecture and civil engineering (AARCV 2012), Bangalore held on 21st-23rd 2012, vol. 21, pp. 119.
    20. Jung S., Kwon S. J. Engineering properties of cement mortar with pond ash in South Korea as construction materials: from waste to concrete. Open Engineering, 2013, vol. 3, no. 3, pp. 522-533.
    21. Cheerarot R., Jaturapitakkul C. A study of disposed fly ash from landfill to replace portland cement. Waste Management, 2004, vol. 24, no. 7, pp. 701-709.
    22. Lunev A. A., Yavinskiy A. V. Bearing capacity of inert ash-and-slag mixtures of different genesis. Construction and Geotechnics, 2021, vol. 12, no. 2, pp. 26-41. (In Russ.). doi: 10.15593/2224-9826/2021.2.03
    23. Lebedev M. S., Strokova V. V, Potapova I. Yu., Kotlyarskiy E. V. Effect of additives of low-calcium fly ash from TPP on the characteristics of road bituminous binder. Stroitel'nye materialy, 2014, no. 11, pp. 8-11. (In Russ.).
    24. Kapustin F. L., Ufimcev V. M. Russian standards for using ash and slag from thermal power plants in the production of building materials. Zoloshlaki TES: udalenie, transport, pererabotka, skladirovanie: materialy II Mezhdunar. nauchn.-prakt. seminara [TPP ash and slag: removal, transport, processing, landfilling: Materials of II International Scientific and Practical Seminar (Moscow, April 23-24, 2009)]. Moscow, MEI Publ., 2009, pp. 57-64. (In Russ.).
    25. Fedyuk R. S., Taskin A. V., Grebenyuk I. V., Yolkin O. I. Application of ash-and-slag wastes from thermal power plants as a cement binder. Sb. dokl. XIX Vseross. nauchn.-prakt. konf. "Dni nauki-2019" [XIX All-Russian scientific and practical conference "Days of Science-2019" (April 17-20, 2019)]. Ozyorsk, OTI NIYAU MIFI Publ., 2019, pp. 67-71. (In Russ.).
    26. Lishtvan I. I., Dudarchik V. M., Krayko V. M. Quality criteria, classification and directions of ash utilization from solid fuel combustion. Prirodopol'zovanie, 2014, no. 25, pp. 184-195. (In Russ.).
    27. Dvorkin L. I. The influence of polyfunctional modifier additives on properties of cement-ash fine-grained concrete. Magazine of Civil Engineering, 2020, no. 1(93), pp. 121-133. doi: 10.18720/MCE.93.10
  • For citation: Yavinskiy A. V., Chulkova I. L. Influence of the Specific Surface Area of Hydro-removal Ash on the Properties of Ash-cement Stone. Promyshlennoe i grazhdanskoe stroitel'stvo [Industrial and Civil Engineering], 2023, no. 2, рp. 73-80. (In Russ.). doi: 10.33622/0869-7019.2023.02.73-80

BACK